Dr-power RapidFire 6 HP Subaru (July 2012 - Aug 2013) Manuel d'utilisateur

Read and understand this manual and all instructions before operating the DR RAPIDFIRE LOG SPLITTER. Original Language DR® RAPIDFIRE™ LOG SPLITTER S

10 DR® RAPIDFIRE™ LOG SPLITTER Operator Zone Figure 6 TOP VIEW Operator Zone Chapter 3: Operating The DR RAPIDFIRE LOG SPLITTER It may be help

CONTACT US AT www.DRpower.com 11 Hands on Sides of WoodFigure 12 Wood Against Wedge Splitting Note: All logs should be no longer than 24&quo

12 DR® RAPIDFIRE™ LOG SPLITTER Chapter 4: Maintaining The DR RAPIDFIRE LOG SPLITTER Regular maintenance is the way to ensure the best performa

CONTACT US AT www.DRpower.com 13 3. Grease the Rack Teeth with All Purpose Grease (Figure 16). 4. Push the Carriage assembly back into star

14 DR® RAPIDFIRE™ LOG SPLITTER 4. Remove the Spring retainer Hardware on both sides of the Ram using two 7/16" Wrenches (Figure 20). 5.

CONTACT US AT www.DRpower.com 15 3. Remove the Bolt, Lock Washer and large Flat Washer from the Clutch with a 1/2" Wrench and remove th

16 DR® RAPIDFIRE™ LOG SPLITTER 7. Position the linkage assembly into the Frame in the correct orientation (Figure 28) and install the Pivot P

CONTACT US AT www.DRpower.com 17 Replacing the Wheels Tools and Supplies needed:  Needle Nose Pliers  Jack 1. Jack the Splitter until a

18 DR® RAPIDFIRE™ LOG SPLITTER Charging the Battery Operate the Engine for at least 45 minutes to maintain proper Battery charge. If the Batt

CONTACT US AT www.DRpower.com 19 Chapter 5: Troubleshooting Most problems are easy to fix. Consult the Troubleshooting Table below for common

2 DR® RAPIDFIRE™ LOG SPLITTER This indicates a hazardous situation, which, if not avoided, could result in death or serious injury. Table of C

20 DR® RAPIDFIRE™ LOG SPLITTER Troubleshooting Table (Continued) SYMPTOM POSSIBLE CAUSE Rack slamming back too fast.  Wedge end of machine t

CONTACT US AT www.DRpower.com 21

22 DR® RAPIDFIRE™ LOG SPLITTER Chapter 6: Parts Lists and Schematic Diagrams Parts List - TOW BAR AND AXLE ASSEMBLY NOTE: Part numbers listed

CONTACT US AT www.DRpower.com 23 Schematic – TOW BAR AND AXLE ASSEMBLY

24 DR® RAPIDFIRE™ LOG SPLITTER Parts List – DRIVE ASSEMBLY NOTE: Part numbers listed are available through DR Power Equipment. Ref# Part# Des

CONTACT US AT www.DRpower.com 25 Schematic – DRIVE ASSEMBLY

26 DR® RAPIDFIRE™ LOG SPLITTER Parts List – LINKAGE AND BATTERY ASSEMBLY NOTE: Part numbers listed are available through DR Power Equipment. R

CONTACT US AT www.DRpower.com 27 Schematic – LINKAGE AND BATTERY ASSEMBLY

75 MEIGS ROAD, P.O. BOX 25, VERGENNES, VERMONT 05491 ©2012 Country Home Products, Inc. All rights reserved 312421 Daily Checklist for the DR LOG SPL

CONTACT US AT www.DRpower.com 3 Read this Safety & Operating Instructions manual before you use the DR RAPIDFIRE LOG SPLITTER. Become fa

4 DR® RAPIDFIRE™ LOG SPLITTER This is a high-powered machine, with moving parts operating with high energy. You must operate the machine safe

CONTACT US AT www.DRpower.com 5 Gasoline is a highly flammable liquid. Gasoline also gives off flammable vapor that can be easily ignited an

6 DR® RAPIDFIRE™ LOG SPLITTER General Safety A Note to All Users Under California law, and the laws of some other states, you are not permitt

CONTACT US AT www.DRpower.com 7 Figure 1 Pneumatic Tires Oil Fill Starter Cord Gas FillEngagement Handle Splitting Wedge Belt Tensioner Crad

8 DR® RAPIDFIRE™ LOG SPLITTER Specifications RapidFire Pro RapidFire Pro-XL (manual start) RapidFire Pro-XL (elec. start) Engine DR 5.5hp (

CONTACT US AT www.DRpower.com 9 Gas CapFigure 3 4. Continue adding a few ounces of oil at a time, rechecking the Dipstick until the oil reac